Open Access
Kinetics of the acid-catalyzed hydrolysis of tetraethoxysilane (TEOS) by 29Si NMR spectroscopy and mathematical modeling
(Springer, 2018) Echeverría Morrás, Jesús; Moriones Jiménez, Paula; Arzamendi Manterola, Gurutze; Garrido Segovia, Julián José; Gil Idoate, María José; Cornejo Ibergallartu, Alfonso; Martínez Merino, Víctor; Química Aplicada; Kimika Aplikatua; Institute for Advanced Materials and Mathematics - INAMAT2
Tetraethoxysilane (TEOS) is widely used to synthesize siliceous material by the sol–gel process. However, there is still some disagreement about the nature of the limiting step in the hydrolysis and condensation reactions. The goal of this research was to measure the variation in the concentration of intermediates formed in the acid-catalyzed hydrolysis by 29Si NMR spectroscopy, to model the reactions, and to obtain the rate constants and the activation energy for the hydrolysis and early condensation steps. We studied the kinetics of TEOS between pH 3.8 and 4.4, and four temperature values in the range of 277.2–313.2 K, with a TEOS:ethanol:water molar ratio of 1:30:20. Both hydrolysis and the condensation rate speeded up with the temperature and the concentration of oxonium ions. The kinetic constants for hydrolysis reactions increased in each step kh1 < kh2 < kh3 < kh4, but the condensation rate was lower for dimer formation than for the formation of the fully hydrolyzed Si(OH)4. The system was described according to 13 parameters: six of them for the kinetic constants estimated at 298.2 K, six to the activation energies, and one to the equilibrium constant for the fourth hydrolysis. The mathematical model shows a steady increase in the activation energy from 34.5 kJ mol−1 for the first hydrolysis to 39.2 kJ mol−1 in the last step. The activation energy for the condensation reaction from Si(OH)4 was ca. 10 kJ mol−1 higher than the largest activation energy in the hydrolytic reactions. The decrease in the net positive charge on the Si atom contributes to the protonation of the ethoxy group and makes it a better leaving group.
Open Access
Comprehensive kinetics of hydrolysis of organotriethoxysilanes by 29Si NMR
(American Chemical Society, 2019) Moriones Jiménez, Paula; Arzamendi Manterola, Gurutze; Cornejo Ibergallartu, Alfonso; Garrido Segovia, Julián José; Echeverría Morrás, Jesús; Ciencias; Zientziak; Institute for Advanced Materials and Mathematics - INAMAT2
The kinetics of several representative hybrid precursors were studied via 29Si NMR: three alkyl precursors, methyltriethoxysilane, ethyltriethoxysilane, and propyltriethoxysilane; as well as two unsaturated radicals, vinyltriethoxysilane and phenyltriethoxysilane. The reaction rate is related to the chemical shift of 29Si in the NMR spectra, which gives information about the electronic density of the Si atoms and the inductive effects of substituents. The concentration of the precursors decreased exponentially with time, and the intermediate products of hydrolysis and the beginning of the condensation reactions showed curves characteristic of sequential reactions, with a similar distribution of the species as a function of the fractional conversion. For all of the precursors, condensation started when the most hydrolyzed species reached a maximum concentration of 0.30 M, when the precursor had run out. A prediction following the developed mathematical model fits the experimental results in line with a common pathway described by eight parameters.
Open Access
Acid-catalyzed etherification of glycerol with tert-butanol: reaction monitoring through a complete identification of the produced alkyl ethers
(MDPI, 2023) Cornejo Ibergallartu, Alfonso; Reyero Zaragoza, Inés; Campo Aranguren, Idoia; Arzamendi Manterola, Gurutze; Gandía Pascual, Luis; Ciencias; Zientziak; Institute for Advanced Materials and Mathematics - INAMAT2
Higher tert-Butyl glycerol ethers (tBGEs) are interesting glycerol derivatives that can be produced from tert-butyl alcohol (TBA) and glycerol using an acid catalyst. Glycerol tert-butylation is a complex reaction that leads to the formation of five tBGEs (two monoethers, two diethers, and one triether). In order to gain insight into the reaction progress, the present work reports on the monitoring of glycerol etherification with TBA and p-toluensulfonic acid (PTSA) as homogeneous catalysts. Two analytical techniques were used: gas chromatography (GC), which constitutes the benchmark method, and( 1)H nuclear magnetic resonance (H-1 NMR), whose use for this purpose has not been reported to date. A method for the quantitative analysis of tBGEs and glycerol based on H-1 NMR is presented that greatly reduced the analysis time and relative error compared with GC-based methods. The combined use of both techniques allowed for a complete quantitative and qualitative description of the glycerol tert-butylation progress. The set of experimental results collected showed the influence of the catalyst concentration and TBA/glycerol ratio on the etherification reaction and evidenced the intrinsic difficulties of this process to achieve high selectivities and yields to the triether.

Arzamendi Manterola, Gurutze

Email Address

person.page.identifierURI

Birth Date

Job Title

Last Name

First Name

person.page.departamento

person.page.instituteName

ORCID

person.page.observainves

person.page.upna

Name

Filters

Author

Subject

Date

Has files

Item Type

Type

Settings

Sort By

Results per page

Search Results